News: "Historic coin press returning to operation at Nevada State Museum".....Calling Dan Carr!!
Goldbully
Posts: 17,439 ✭✭✭✭✭
Historic coin press returning to operation at Nevada State Museum
Nevada Appeal.....June 20, 2017
In February 1870, the sparkling new steam-powered coin press inside the U.S. Mint in Carson City struck its first coin, a Seated Liberty silver dollar with a crisp CC mint mark.
One hundred and forty seven years, millions of dollars, a couple of road trips and a healthy dose of serendipity later, Press No. 1 is still pressing metal into medallions in the same building in which it started.
"It's still in operation, still doing what it was intended to do," said Myron Freedman, director of the Nevada State Museum, which occupies the former U.S. Mint building. "We are pretty proud to be able to use it for its historically intended purpose."
After being down for several months for repairs, the press is expected to be back in operation in September, pressing medallions for the public's view and purchase — but with a variation. The medallions the press will produce will be smaller, 30 millimeters, than the silver dollar-size of past years.
The change is being made at the urging of a coin press consultant (structural engineers) from the Oakland, Calif.-based company that repaired the 12,000-pound press, from a restoration specialist at the Nevada State Railroad Museum and from independent analysts. They say the striking pressure required to imprint designs onto the blank coins — between 150 and 170 tons — is more than the 147-year-old press can handle. Switching to smaller medals, about half dollar sized, can be done with less strike pressure (a maximum of 110 tons) and therefore, less stress on the machine. Decreasing the tonnage will aid in the preservation of the press.
Finding replacement parts for the machine is difficult to impossible and in many cases the parts, and often the tools to remove and replace them, have to be fabricated from scratch. It also creates a dilemma for historians.
"Our No. 1 priority as a museum is to protect the artifact," Freedman said. "We love being able to produce these medallions and to share that process with the public, but we also must recognize this is an important artifact in Nevada's history."
Freedman said historical research has shown the press, which was built in 1869 by Morgan & Orr in Philadelphia, was designed to press at a much-lower tonnage than the 200 tons it operated at in its early years.
In 1878, it suffered a catastrophic failure, a cracked arch, which put it out of commission for a time. Machinists at the local shop of the Virginia & Truckee Railroad repaired it, and proud of their handiwork, replaced the original brass plate bearing the name Morgan & Orr with their own.
Between 1870 and 1893, the Carson City Mint produced nearly $50 million (face value) of gold and silver coins, including gold double eagles ($20) and eagles ($10), half eagles ($5), silver dollars, half dollars, quarters, dimes and 20-cent pieces.
Today, coins with the CC Mint mark are highly prized by collectors and among the most valuable in the collecting world. An 1873 Carson City dime with no arrows — the only one of its kind known to still exist — sold at auction for $1.8 million in 2012.
"Over the last 45 years, the Carson City coins have just skyrocketed in popularity in the numismatic community," said Rusty Goe, a prominent coin dealer, collector and author of the 2003 book, "The Mint on Carson Street."
"You can't have any more special relic than the coin press that made these coins," Goe said.
The historic dime was certainly pressed in Coin Press 1, which was the only press at the mint until 1875. Eventually, three coin presses operated there as demand for the coins grew.
The Carson City Mint ceased coin production in 1893 and the presses were removed in 1899. Press No. 1 was moved to the Philadelphia Mint, where it was remodeled in 1930 to operate with electric power. In 1945, it was transferred to the San Francisco Mint and renumbered "5" to correspond with its place in the coining department there.
In 1955, when all coin production was temporarily halted at the San Francisco Mint, the old press was targeted to be scrapped. If not for an eagle-eyed Oakland newspaperman who was also an avid Carson City Mint coin collector by the name of Frederick Monteagle, the press might have ended up on the scrap heap of history.
"He's the guy in 1958 who sent word to Nevada that they were scrapping the press," Goe said. "We owe him a big debt of gratitude."
With Monteagle acting as the middleman, Nevada State Museum founder Clark J. Guild and the museum board of trustees were able to buy the press for the state for $225 and it returned to its original home inside the Nevada State Museum.
For the next six years it was a popular artifact in the museum, but in 1964, U.S. Mint director Eva Adams, herself a native Nevadan, was faced with a severe coin shortage and requested the loan of the press. It was trucked to the Denver Mint and operated for the next three years, striking more than 188 million coins during that time.
In 1967, Press No. 1 returned to the Nevada State Museum for good and converted to a slower electric drive. Through the years, it has produced dozens of memorable — and collectible — medallions.
In 1975-76, it produced a coin commemorating the country's bicentennial.
"That was a very important beginning," said Bob Nylen, curator of history at the Nevada State Museum. "Over the years, we've done medallions for state agencies and the public and private sector. It's been quite a lot of projects."
Projects for the Pony Express, V&T Railroad Reconstruction, Abraham Lincoln Bicentennial, and Nevada's sesquicentennial and, most recently, a coin commemorating the Nevada State Museum's 75th birthday, have all been completed on Press No. 1.
One of the most memorable days for Nylen and longtime volunteer and coiner Ken Hopple, was in 2006, when commemorative coins were minted to coincide with the release of the Nevada state quarter.
A huge crowd assembled at the museum on that cold January day to acquire one of the newly minted "Spirit of the West" medallions, purchasing them as soon as they left the press.
Being able to see the historic press in action is something unique for visitors to the museum, Freedman said, and something the museum wants to continue.
"Thousands of visitors have been delighted to see the press in operation during demonstrations given by volunteer and local favorite Ken Hopple, and to purchase medallions in the museum gift shop," Freedman said.
Comments
Working to produce coinage for nearly 100 years and still producing medals - that's super cool!
https://www.banknotebank.com/security/users/login
@Goldbully - Thanks for posting this! Very cool indeed!
That is pretty cool that the man responsible for rescue and preservation of the press that pressed so many eagles and double eagles was himself an eagle:
"In 1955, when all coin production was temporarily halted at the San Francisco Mint, the old press was targeted to be scrapped. If not for an eagle-eyed Oakland newspaperman who was also an avid Carson City Mint coin collector by the name of Frederick Monteagle, the press might have ended up on the scrap heap of history.
"He's the guy in 1958 who sent word to Nevada that they were scrapping the press," Goe said. "We owe him a big debt of gratitude."
With Monteagle acting as the middleman, Nevada State Museum founder Clark J. Guild and the museum board of trustees were able to buy the press for the state for $225 and it returned to its original home inside the Nevada State Museum."
Here is a link to my photo essay depicting the press in operation with Mint Director Bob Nylen and Ken Hopple pictured as it is being operated.
The link includes examples of two of the now no longer to be available dollar sized commemorative coins that I acquired, one of which you can see as it was being pressed for me.
There are also some great responses in the thread worth clicking including some video links showing the press working.
https://forums.collectors.com/discussion/914924/remembering-the-pony-express-at-the-carson-city-mint-a-photo-essay
Wow, what a great thread. Sorry I missed it the first time. Great job @northcoin.
edited to add: I did a search for "press" and really nothing came up.
So they're moving to half dollar size huh. I have a dozen or so of the "old" ones. Wonder if they'll start going higher in the aftermarket now.
BTW, we all know Dan has a more modern press but another private mint, can't remember which one right now, just bought one of this model and is or was in the process of setting it up, self refurbishing it and tuning it in. They may not like the conclusion of these refurbishers about strike pressure.
Great thread. Historic and informative with super references. Thanks Goldbully and northcoin for posting.
CascadeChris;
Would you post more about the dozen or so "old" ones you have and how they are listed in the market?
Great thread .... as was the older one linked.... The Carson City Morgans are the only mint mark series I have collected - and completed. Something about that CC mint mark on big silver... fascinates me almost as much as gold coins....
Cheers, RickO